Roadside Inspection 80618795
Roadside inspection on Jan 11, 2024 in Texas • Carrier: EL PILON TRUCKING LLC (USDOT 3621630) • Vehicle: PTRB TRUCK TRACTOR
Vehicle OOS
Driver: OK
CVSA L2
Inspection Details
Key facts from the FMCSA inspection record.
- Inspection #:
- 80618795
- Date:
- Jan 11, 2024
- State:
- Texas
- Level:
- Level II — Walk-Around
- Type:
- —
- Units inspected:
- 2
- Violations:
- 9
- HazMat:
- No
- Inspection site:
- TW-SRT IN DENTON CO. (2155-246
- Carrier (USDOT):
- EL PILON TRUCKING LLC (3621630)
- Vehicle:
- PTRB TRUCK TRACTOR
- Plate:
- 1L90709 (TX)
- VIN:
- 1XP5DB9X1YD526355
What this inspection means
The vehicle was placed out of service at this inspection.
Compared to the median Level 2 inspection nationwide in 2024, this is a more severe than typical result.
Severity context
How mild, normal, or severe was this inspection compared to its carrier, state, and station?
vs Level 2 median in Texas
9
Heavier than median (2)
Median of 176,960 Level 2 inspections in Texas during 2024
How this compares
National peer benchmarks for inspections at this level.
Violations vs Level 2 median
9
8 more than the median (1)
Compared to 941,515 Level 2 inspections nationwide in 2024
OOS at this inspection
Yes
Cohort OOS rate: 26.0%
Out-of-service rate across all Level 2 inspections in 2024
Units Inspected
2 unit(s) covered by this inspection.
| Seq | Type | VIN | Plate | Make | Model | Year | OOS |
|---|---|---|---|---|---|---|---|
| 1 | TRUCK TRACTOR | 1XP5DB9X1YD526355 | TX 1L90709 | PTRB | — | — | — |
| 2 | SEMI-TRAILER | 48X1F3729J1012784 | TX 185B622 | TRVS | — | — | — |
Violations Cited
9 violation(s) recorded against this inspection.
| Code | Description | Severity Wt | BASIC | OOS |
|---|---|---|---|---|
| 392.2 | Operating a CMV while ill or fatigued | 8 | Unsafe Driving | — |
| 396.5(b) | Fuel system leak | 7 | Vehicle Maintenance | — |
| 393.75(c) | Tire tread depth insufficient (other axles) | 5 | Vehicle Maintenance | — |
| 393.78 | Windshield condition defective | 4 | Vehicle Maintenance | — |
| 393.11 | Lighting devices/reflectors | 3 | Vehicle Maintenance | — |
| 393.9(a) | Inoperable required lamps | 3 | Vehicle Maintenance | — |
| 393.9(a) | Inoperable required lamps | 3 | Vehicle Maintenance | — |
| 393.209(e) | Power steering violations | — | Vehicle Maintenance | — |
| 393.75(a)(3) | Tire-flat and/or audible air leak | — | Vehicle Maintenance | OOS |
Violation categories (BASICs)
Federal behavior-analysis-and-safety-improvement buckets for the cited violations.
Nearby inspections (same carrier, ±60 days)
Other times this carrier was inspected around the same date.
| Inspection | Date | State | Level | Location | Violations | OOS |
|---|---|---|---|---|---|---|
| 80348076 | Dec 7, 2023 | TX | L2 | US380 EB | 2 | — |
| 80243975 | Nov 20, 2023 | TX | L2 | US 380 EB | 5 | — |
Other inspections of these vehicles
History for the VINs recorded on this inspection.
| Inspection | Date | State | Level | VIN | OOS |
|---|---|---|---|---|---|
| 87539074 | Apr 3, 2026 | TX | L1 | 1XP5DB9X1YD526355 | OOS |
| 86865298 | Jan 17, 2026 | TX | L2 | 1XP5DB9X1YD526355 | OOS |
| 80348076 | Dec 7, 2023 | TX | L2 | 1XP5DB9X1YD526355 | — |
| 80348076 | Dec 7, 2023 | TX | L2 | 48X1F3729J1012784 | — |
| 80243975 | Nov 20, 2023 | TX | L2 | 1XP5DB9X1YD526355 | — |
| 80243975 | Nov 20, 2023 | TX | L2 | 48X1F3729J1012784 | — |
| 79656472 | Aug 17, 2023 | TX | L2 | 1XP5DB9X1YD526355 | — |
| 79656472 | Aug 17, 2023 | TX | L2 | 48X1F3729J1012784 | — |
Related records
Carrier
EL PILON TRUCKING LLC
Full carrier record and safety profile.
Station
TW-SRT IN DENTON CO. (2155-246
All inspections at this site.
State
Inspections in Texas
Statewide inspection records.
Level
Level II — Walk-Around
All inspections at this CVSA level.
Vehicle
VIN 1XP5DB9X1YD526355
All inspections and records for this VIN.
Plate
1L90709 (TX)
All inspections tied to this plate.
Reference
FMCSR Violations
Violation-code reference library.
How to use this inspection record
- Confirm the inspection ID and date. Verify that the inspection number (80618795) and date (Jan 11, 2024) match what the carrier or broker has provided you. The inspection ID is FMCSA's permanent identifier and will not change.
- Review every cited violation code. Click through each violation code in the table below to read the underlying FMCSR section. The severity weight column tells you which citations carry the most weight in the SMS scoring algorithm.
- Check the OOS flags. An OOS order was issued. The Vehicle OOS / Driver OOS badges at the top of this page tell you which side of the cab triggered it; until the cited defects were corrected, the carrier could not legally continue operating.
- Compare against the carrier's broader inspection history. Open the carrier's full inspection page to see whether this result is typical or an outlier: /usdot/3621630/inspections/
- Cross-reference with SMS BASIC scoring. Open the carrier profile to see how the BASICs cited here aggregate across the carrier's full scoring window: /usdot/3621630/
Frequently asked questions about this inspection
What does a roadside inspection Level 2 actually inspect? ▾
A Level II (Walk-Around) inspection covers the same items as a Level I but the inspector does not physically get under the vehicle. Inspectors record any out-of-service violations on the spot.
Was this inspection an OOS event for this carrier? ▾
Yes — this inspection produced an out-of-service order against the vehicle. OOS orders prohibit further operation until the cited defects are corrected.
How does this inspection compare to the carrier's recent record? ▾
There is not yet enough prior inspection history on this carrier to compute a meaningful comparison. Once a carrier has at least 10 inspections on record, this page surfaces a 30/90/365-day trend ribbon.
What violation codes were cited and what do they mean? ▾
Is this carrier still operating after this inspection? ▾
An inspection is a snapshot — it does not by itself terminate operating authority. To check current operating status for this carrier, see the live carrier profile, which reflects FMCSA's most recent authority and out-of-service status.
How long does an inspection result stay on a carrier's record? ▾
Inspection records are permanent in FMCSA's Motor Carrier Management Information System (MCMIS). For the purpose of the SMS BASIC scoring algorithm, however, time-decayed weights mean inspections older than 24 months count less, and inspections older than 36 months drop out of the scoring window altogether.
How does this inspection feed into FMCSA's SMS BASIC scoring? ▾
Each cited violation has a severity weight (visible in the Violations Cited table) and a BASIC category (Vehicle Maintenance, HOS Compliance, Unsafe Driving, etc.). FMCSA aggregates these weighted citations across all of a carrier's inspections in the scoring window to produce a percentile score per BASIC. OOS violations carry a +2 weight bump.
Where can I see all inspections for this carrier? ▾
The full inspection history is available at /usdot/3621630/inspections/, including filters for level, state, OOS status, and BASIC category.
Recent activity at TW-SRT IN DENTON CO. (2155-246
Other carriers inspected here recently.
| Inspection | Date | Carrier | Violations | OOS |
|---|---|---|---|---|
| 87573647 | Apr 10, 2026 | US LBM LOGISTICS LLC | 2 | OOS |
| 87573480 | Apr 10, 2026 | TEXAS SHAFTS INC | 9 | OOS |
| 87573332 | Apr 10, 2026 | LEOS BROTHERS TRUCKING LLC | 18 | OOS |
| 87513587 | Apr 3, 2026 | MELGAR TRANSPORT LLC | 2 | — |
| 87512934 | Apr 3, 2026 | JDJ LOGISTICS LLC | 9 | OOS |
| 87513478 | Apr 2, 2026 | WILD BILL AND SONS LLC | 8 | OOS |
Data sources & freshness
TruckCodex aggregates official public-sector datasets. See the Source registry for dataset-level coverage and the Freshness log for last-import timestamps.
Census, SAFER, SMS, Licensing & Insurance (L&I), roadside inspections, crashes, and authority history.
Refreshed daily.
Vehicle recall campaigns, defect investigations, and consumer safety complaints (SCRS).
Refreshed daily.
Cross-border carrier registry and Canadian recall campaigns where applicable.
Refreshed weekly.
TruckCodex is an independent aggregator; it is not affiliated with FMCSA, NHTSA, EIA, or Transport Canada. Always verify compliance-critical information directly with the originating agency.