Complaint 2218522

Complaint Summary

SERVICE BRAKES

Owner Narrative

On Monday [XXX] were driving on [XXX] going north up [XXX]. I was doing about 60-65 mph in traffic which was flowing in both directions. While ascending the pass, the car suddenly started to misfire, rapidly lost power, power steering failed and all dash lights lit up. With no shoulder to pull out this was a very scary experience. Eventually managed to limp to a spot where I could pull out off the pavement. Car was dead. Popping the hood showed significant battery corrosion. I had a toolkit with me. The voltmeter measured the battery voltage at 9.3V. Thinking maybe cleaning the battery terminals would allow the car to be restarted, I managed to get the cables off and cleaned everything with a wire brush. But still no power. After a while a state trooper passed by and hung on while I contacted a towing service. After another 1.5 hours, the tow truck arrived and towed the car the 60 miles or so to the dealership in Denver with my wife and I in the cab of the tow truck. Dealer repair invoice indicated Data Control Module (DCM) "causing excessive draw on electrical system." More significantly, the battery had drained below the the operating threshold voltage required for vehicle drivability (understood to be 10-10.5V). There was no mention of this by the dealer service adviser. Although dealer diagnostic was carried out, no computer codes were provided. Vehicle mileage at time of incident 73,456. I have owned the car since new and have all service records. Car was repaired and picked up from dealership on 06/10/26 with a replacement DCM. Battery was charged up but not replaced and left in corroded state. Battery will probably have been weakened by such a total discharge with reduced life expectancy. I have uploaded the dealer repair invoice. I have reported this incident to Subaru of America. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Owner-submitted narrative on file with NHTSA. Complaint narratives are self-reported and have not been verified.