Complaint 2204628

Complaint Summary

UNKNOWN OR OTHER

Owner Narrative

On March 26, 2026, my vehicle received the rear suspension toe link replacement under Ford/NHTSA Recall 26S08 (26V101000). Within approximately 5 weeks, all four rear tires were completely destroyed by misalignment caused by Ford’s non-adjustable replacement parts. On approximately May 2, 2026 — during the first rain after the recall service — my vehicle hydroplaned and skidded uncontrollably, creating a serious risk of collision and injury. On May 4, 2026, Mavis Tire & Brake [XXX] ) confirmed the cause: Ford’s non-adjustable recall toe link replacement had left my rear wheels severely out of alignment (rear total toe measured 2.09° — over 4x outside the acceptable range of 0.10°–0.50°). The Mavis Service Manager documented in writing on Invoice #21381: “REPLACED REAR ARMS WITH ADJUSTABLE ARMS TO CORRECT ALIGNMENT.” The Mavis technician noted I was the second Ford Explorer customer within the same few weeks to present with this identical defect. I paid $1,507.93 out of pocket for four replacement tires, two new adjustable control arms to replace Ford’s defective recall parts, and alignment service. KEY EVIDENCE IN MY POSSESSION: • Mavis Invoice #XXX ($1,507.93) with Service Manager’s written admission • Pre- and post-repair alignment reports showing extreme misalignment and full correction • Photographs of destroyed Bridgestone Alenza 255/50R20 tires (severe inner-edge wear) • Ford dealership video from March 26, 2026 showing tires in good condition before recall service • VIN door sticker confirming vehicle specs • Complete case overview document prepared for submission INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Owner-submitted narrative on file with NHTSA. Complaint narratives are self-reported and have not been verified.