Complaint 2181357

Complaint Summary

ELECTRICAL SYSTEM

Owner Narrative

I have a 2025 Hyundai Kona Limited. On [XXX], around the afternoon on Sunnyvale, California, while exiting [XXX] headed to Lake Tahoe, the liftgate bolt that attaches to the body had buckled mechanically as the system did not back away when a flashlight that came out of a travel bag was blocking the way to have it closed. The car computer thinks the liftgate is open even though the lock is secured. The car computer allows to drive without seatbelts secured or closures ajar for a few seconds at low speed but then it automatically with little warning engages the electronic handbrake while driving. I was driving on a highway in a middle lane when the car engaged without my consent the electronic handbrake locking the wheels and I almost got rear ended and killed by a semitruck. I had to floor the gas pedal and steer to a shoulder to request a tow. Since it was a long weekend before Presidents Day, I had the car taken to the nearest dealer in Modesto California. Their service department invented a lie that due to a side crash, which was a failure of the collision mitigation system that happened months ago, is the cause and that it is my fault even though the driver admitted responsibility but it is an unrelated issue. There should be a way of overriding the car computer so it does not engage the electronic hand brake on the middle of the highway, specially at night as this creates a road hazard that can lead to death. I replicate the issue with a rental, a Hyundai Tucson, they use the same gas strut and bolt that in my opinion has a very narrow gage. As you can see in the picture, the passenger side bolt is fine, the driver side is buckled. The side accident that happened on May 2025 was on the passenger side but the liftgate is fine; at any rate both sides should be deformed not just one if that were to be the case but it is not. Dealer and Hyundai attempting to sideline the issue to avoid a warranty and recall in my opinion. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Owner-submitted narrative on file with NHTSA. Complaint narratives are self-reported and have not been verified.